All Issue

2025 Vol.16, Issue 4 Preview Page

General Article

Simulation of chloride diffusion and structural performance evaluation of sound and corroded RCC beams
Prakhar Singh1
,
Hanseung Lee2*
1MS Student, Smart City Engineering, Hanyang University, Sangnok-gu, Ansan, South Korea
2Professor, Department of Architectural Engineering, Hanyang University, Sangnok-gu, Ansan, South Korea
*Corresponding Author
31 December 2025. pp. 510-520
PDF XML Citation
Abstract

This study describes the structural behavior of RC beams when subjected to different levels of corrosion by developing a finite element model, subsequently validating it with the help of experimental results. The analysis was run using ABAQUS to represent both the mechanical response as well as chloride diffusion within the beam. Validation data were adopted from earlier literature. The sound beam model has been validated first by comparing its load-deflection response against one derived from experiments with less than 5% deviation in ultimate load and very close agreement. The validated model was then used to simulate 10% and 20% corrosion levels, derived from the experimental corrosion equations, to assess the degradation in structural capacity. The result showed that the corrosion led to a clear deterioration of structural behavior, ultimate load decreased by approximately 17% for 10% and 33% for 20% corrosion, while peak bond stress from 7.2 MPa (sound beam) to 5.0 MPa and 2.5 MPa, respectively. A long term chloride diffusion analysis was performed to estimate the corrosion initiation, revealing that after 100 years of exposure the chloride ion reached the reinforcement depth, indicating a high probability of corrosion. The combined mechanical and diffusion analysis result demonstrate that corrosion significantly reduced stiffness, load carrying capacity, and bond resistance. Overall, the proposed FEM approach provides a reliable numerical framework for evaluating the mechanical performance and deterioration of RC beams affected by corrosion.

Keywords
reinforced concrete beam
finite element modeling
load-deflection behavior
chloride diffusion
corrosion
bond stress
References
1

G.H. Koch, M.P.H. Brongers, N.G. Thompson, Y.P. Virmani, and J.H. Payer, Corrosion cost and preventive strategies in the United States. No. FHWA-RD-01-156, R315-01. United States. Federal Highway Administration, 2002.

2

S. Williamson and L.A. Clark, Effect of corrosion and load on reinforcement bond strength. Struct. Eng. Int. (IABSE, Zurich, Switzerland). 12(2) (2002), pp. 117-122.

10.2749/101686602777965559
3

H.S. Lee, N. Takafumi, and T. Fuminori, Evaluation of the bond properties between concrete and reinforcement as a function of the degree of reinforcement corrosion. Cement and Concrete research. 32(8) (2002), pp. 1313-1318.

10.1016/S0008-8846(02)00783-4
4

J. Němeček, J. Kruis, T. Koudelka, and T. Krejčí, Simulation of chloride migration in reinforced concrete. Applied Mathematics and Computation. 319 (2018), pp. 575-585.

10.1016/j.amc.2017.07.029
5

H.S. Lee, T. Noguchi, and F. Tomosawa, Analytical evaluation of structural performance of reinforced concrete beams considering degree of reinforcing bar corrosion. Proceedings of Fourth International Conference on Repair, Rehabilitation and Maintenance of Concrete Structures and Innovations in design and Construction, Seoul, Korea, SP 193-46 (2000), pp. 779-789.

6

K. Bhargava, A.K. Ghosh, Y. Mori, and S. Ramanujam, Corrosion-induced bond strength degradation in reinforced concrete-Analytical and empirical models. Nuclear Engineering and Design. 237(11) (2007), pp. 1140-1157.

10.1016/j.nucengdes.2007.01.010
7

T. Tejaswini and M.V. Rama Raju, Analysis of RCC Beams using ABAQUS International Journal of Innovations in Engineering and Technology (IJIET) 5 June, 2015.

8

S.M. Soleimani and S.S. Roudsari, Analytical Study of Reinforced Concrete Beams Tested under Quasi-Static and Impact Loadings. Journal of Applied Sciences. 9 (2019).

10.3390/app9142838
9

O.O. Ayinde, X.B. Zuo, and G.J. Yin, Numerical simulation of concrete degradation due to chloride-induced reinforcement corrosion. 2018, 2017 3rd International Forum on Energy, Environment Science and Materials (IFEESM 2017). Atlantis Press.

10.2991/ifeesm-17.2018.252
10

B. Ratha, Y. Amit, and M. Bijayananda, Chloride diffusion behaviour and structural performance of basalt fiber-reinforced concrete beam in marine environment. Structures. 61 (2024).

10.1016/j.istruc.2024.106094
11

D.F.O.A. Ingason, Modelling and simulation of reinforced concrete beams Department of Applied Mechanics Division of Solid Mechanics Chalmers University of Technology, Master’s Thesis (2013).

12

C. Andrade, Calculation of Chloride Diffusion Coefficients in Concrete From Ionic Migration Measurements. Cement and Concrete Research. 23(3) (1993), pp. 724-742.

10.1016/0008-8846(93)90023-3
13

C. Andrade and M.A. Sanjuan, Experimental Procedure for the Calculation of Chloride Diffusion Coefficients in Concrete from Migration Tests. Advances in Cement Research. 6(23) (1994), pp. 127-134.

10.1680/adcr.1994.6.23.127
14

H. Sinaei, M. Shariati, A.H. Abna, M. Aghaei, and A. Shariati, Evaluation of reinforced concrete beam behavior using finite element analysis by ABAQUS. Scientific Research and Essays. 7(21) (2012), pp. 2002-2009.

10.5897/SRE11.1393
15

J.E. Hansen and E.S. Victor, Numerical simulation of reinforced concrete deterioration-Part I: Chloride diffusion. ACI Materials Journal. 96 (1999), pp. 173-180.

10.14359/442
16

S. Katayama, K. Maruyama, and T. Kimura, Flexural Behaviour of RC Beams with Corrosion of Steel Bars, The 49th Annual Meeting of Japan Cement Association. Japan Cement Association, Tokyo, Japan. (1995), pp. 880-885.

17

Y. Tachibana, Y. Kajikawa, and M. Kawamura, The behaviour of RC beams damaged by corrosion of reinforcement. Proc. Jpn. Soc. Civ. Eng. 402 (V-10) (1989), pp. 105-114.

10.2208/jscej.1989.402_105
18

P.S. Mangat and M.S. Elgarf, Bond characteristics of corroding reinforcement in concrete beams. Mater. Struct. 32(216) (1999), pp. 89-97.

10.1007/BF02479434
19

G.J. Al-Sulaimani, Degradation of bond between reinforcing steel and concrete due to cathodic protection current. ACI Mater. J. 90 (1) (1993), pp. 8-15.

10.14359/4028
Information
  • Publisher :Sustainable Building Research Center (ERC) Innovative Durable Building and Infrastructure Research Center
  • Publisher(Ko) :건설구조물 내구성혁신 연구센터
  • Journal Title :International Journal of Sustainable Building Technology and Urban Development
  • Volume : 16
  • No :4
  • Pages :510-520
  • Received Date : 2025-11-10
  • Accepted Date : 2025-11-18
  • DOI :https://doi.org/10.22712/susb.20250034
Journal Informaiton International Journal of Sustainable Building Technology and Urban Development International Journal of Sustainable Building Technology and Urban Development
Online Submission
  • scopus
  • NRF
  • KOFST
  • KISTI Current Status
  • KISTI Cited-by
  • crosscheck
  • orcid
  • open access
  • ccl
  • isc
Journal Informaiton Journal Informaiton - close